Related Manuals for Xtreme Power Conversion XC-14A
Summary of Contents for Xtreme Power Conversion XC-14A
- Page 1 Xtreme Cooling Portable Air Conditioners Models: XC-14A, XC-22A, XC-30A User’s & Installation Manual Xtreme Power Conversion® (XPC) Corporation...
-
Page 2: Table Of Contents
XC-14A, XC-22A, XC-30A USER’S MANUAL Portable Air Conditioners Table of Contents IMPORTANT SAFETY INSTRUCTIONS..........4 INTRODUCTION..................6 PRODUCT DESCRIPTION..............6 ASSEMBLY....................7 Component Parts Power Cord Holder Rubber Stoppers Discharge Ducts / Supply Air Duct INSTALLATION GUIDE................9 Moving the Unit Plugging in the Unit OPERATION...................11... - Page 3 Please read this manual before installing the XC-14A, XC-22A, or XC-30A as it provides important information that should be followed during installation and maintenance of the Portable Air Conditioner, allowing you to correctly set up your system for the maximum safety and performance.
-
Page 4: Important Safety Instructions
XC-14A, XC-22A, XC-30A USER’S MANUAL Portable Air Conditioners IMPORTANT SAFETY INSTRUCTIONS: (SAVE THESE INSTRUCTIONS) Please read this manual carefully for instructions on correct installation and usage. Please read all safety instructions. Transport and store the unit in an upright position only. Leave the unit in an upright position for at least 3 hours before use. - Page 5 XC-14A, XC-22A, XC-30A USER’S MANUAL Portable Air Conditioners plug from the electrical outlet. Always turn the unit off and unplug the main power plug from the electrical outlet before cleaning, moving, or performing maintenance. AVOID the use of adapter plugs or extension cords. If it is necessary to use an extension cord or an adapter plug to operate the unit, ensure that they are correctly rated for the application.
-
Page 6: Introduction
XC-14A, XC-22A, XC-30A USER’S MANUAL Portable Air Conditioners INTRODUCTION The information provided in this manual covers 13,200 – 29,000 BTU/HR Xtreme Cooling units, their basic functions, operating procedures, options available and emergency situations. It also includes information on how to ship, store, handle, and install the equipment. -
Page 7: Assembly
XC-14A, XC-22A, XC-30A USER’S MANUAL Portable Air Conditioners ASSEMBLY Component Parts Cool air outlet hose Top fan wire grille Display / Control board Evaporator / filter Guide bar for condensate water tank Condensate water tank (Water level is sensed, and the unit operation is stopped when tank is full. -
Page 8: Power Cord Holder
XC-14A, XC-22A, XC-30A USER’S MANUAL Portable Air Conditioners Power Cord Holder 1. Remove the Power Cord Holder from the accessory box 2. Place the Power Cord Holder on the rear of the unit as shown in Figure 3 3. Use screws to install the Power... -
Page 9: Discharge Ducts / Supply Air Duct
XC-14A, XC-22A, XC-30A USER’S MANUAL Portable Air Conditioners Discharge Ducts / Supply Air Duct 1. Remove the Cool Air Outlet Hose(s) from the box 2. Place the Cool Air Outlet Hose(s) on the front top of the unit as shown in Figure 5 3. -
Page 10: Moving The Unit
XC-14A, XC-22A, XC-30A USER’S MANUAL Portable Air Conditioners Moving the Unit Unlock the casters and push the unit using the side handles to a flat, level surface and set the cater brakes to the locked position. Plugging in the Unit Check the prongs and surface of the power cord plug for dust/dirt. -
Page 11: Operation
XC-14A, XC-22A, XC-30A USER’S MANUAL Portable Air Conditioners OPERATION Control Panel Figure 6 – Control Panel 1. POWER BUTTON Activates unit when POWER BUTTON is pressed. Fan starts on low speed. If POWER BUTTON is pressed during operation, unit stops. -
Page 12: Maintenance
XC-14A, XC-22A, XC-30A USER’S MANUAL Portable Air Conditioners 5. SET TEMP BUTTON Change target temperature / data value by ± 1. Change data value by ± 10 by pressing continually. Press the SET TEMP BUTTONS to set temperature Upper button is to heighten temperature and Lower button is to lower temperature. - Page 13 XC-14A, XC-22A, XC-30A USER’S MANUAL Portable Air Conditioners Pull the filter frame forward to remove the back filter. Figure 7 – Removing Rear Filter Remove dust from the filter using a vacuum cleaner hose attachment. If required, wash the filter in lukewarm water with a mild detergent.
-
Page 14: Spring Replacement
XC-14A, XC-22A, XC-30A USER’S MANUAL Portable Air Conditioners closed position. 5. Replace the clean filter and close the filter guard. 6. To clean the condenser filter, lift up on the rear filter from the middle bar slightly and then angle the filter outwards from the bottom and remove. -
Page 15: Troubleshooting
XC-14A, XC-22A, XC-30A USER’S MANUAL Portable Air Conditioners TROUBLESHOOTING The alarm light is activated if abnormal operation occurs, and a code is displayed on the control panel. The compressor and condenser fan motor will stop operating. The evaporator fan will continue to run for 3 minutes. -
Page 16: Alarm Codes
XC-14A, XC-22A, XC-30A USER’S MANUAL Portable Air Conditioners Alarm Codes SELF-DIAGNOSTIC ALARM CODES Alarm Problem Cause Corrective Action Display Do not use the air Frost prevention Indoor heat exchanger conditioner if ambient sensor and temperature too low temperature is lower than... -
Page 17: Troubleshooting Chart
XC-14A, XC-22A, XC-30A USER’S MANUAL Portable Air Conditioners Troubleshooting Chart Symptom Possible Causes Corrective Action Remove blockage from drain hose High water level in Water leakage Remove any object stuck condensate tank underneath of the black panel under the water tank... -
Page 18: Specifications
XC-14A, XC-22A, XC-30A USER’S MANUAL Portable Air Conditioners Specifications Specifications Unit XC-14A XC-22A XC-30A Cooling Capacity BTU/HR 13,200 21,000 29,000 PHASE Single Single Single Power Supply VOLTS 208 / 230 208 / 230 HERTZ Size (W x D x H) INCHES 17.5 x 19.9 x 43.3... -
Page 19: Shipping List
XC-14A, XC-22A, XC-30A USER’S MANUAL Portable Air Conditioners SHIPPING LIST (1) PORTABLE COOLING UNIT (1) User’s and Installation Manual (1) POWER CORD HOLDER (4) RUBBER STOPPERS DISCHARGE / SUPPLY AIR DUCTS (1) XC-14A (2) XC-22A (3) XC-30A Xtreme Power Conversion® (XPC) Corporation... -
Page 20: Obtaining Service
XC-14A, XC-22A, XC-30A USER’S MANUAL Portable Air Conditioners OBTAINING SERVICE If the Xtreme Cooling unit requires Service: 1. Use the TROUBLESHOOTING section in this manual to eliminate obvious causes. 2. Verify there are no circuit breakers tripped. 3. Call your dealer for assistance. If you cannot reach your dealer, or if they cannot resolve the problem, call Xtreme Power Conversion Corp Technical Support at 800.582.4524. -
Page 21: Xtreme Power Conversion® (Xpc) Corporation Limited Warranty
(XPC) ® CORPORATION LIMITED WARRANTY Xtreme Power Conversion (XPC) Corporation warrants Xtreme Power Conversion equipment, when properly applied and operated within specified conditions, against faulty materials or workmanship for a period of one year for Xtreme Cooling unit from the date of purchase. - Page 22 XPC Corporation or a XPC Corporation authorized representative before or after delivery with regard to the use or application of Xtreme Power Conversion equipment is furnished on the basis that it represents XPC Corporations best judgment under the situation and circumstances, but it is used at the recipient’s sole risk.
-
Page 23: Options
XC-14A, XC-22A, XC-30A USER’S MANUAL Portable Air Conditioners OPTIONS Ambient Air Adaptor Cooling Hose Assembly Exhaust Flanges Temperature Sensor Line Remote Control Pump Kit Xtreme Power Conversion® (XPC) Corporation Page 23... - Page 24 XC-14A, XC-22A, XC-30A USER’S MANUAL Portable Air Conditioners Page 24 Xtreme Power Conversion® (XPC) Corporation...