Table of Contents
Advertisement
Quick Links
Installation, Operation,
& Safety Handbook
Model 1500
Model 2500
1660 Whalebone Dr.
Obadiah's Wood Stoves
Kalispell, MT 59901
www.woodstoves.net
800-968-8604
Model 2500 and 1500
Freestanding Stove or Fireplace Insert
Safety Notice: If this wood stove is not properly installed,
a house fire may result. For your safety, please follow the
installation directions. Contact local building or fire officials
about restrictions and installation inspection in your area.
Advertisement
Table of Contents
Summary of Contents for Obadiah's Wood Stoves 1500
- Page 1 Obadiah's Wood Stoves Kalispell, MT 59901 www.woodstoves.net 800-968-8604 Model 2500 and 1500 Freestanding Stove or Fireplace Insert Safety Notice: If this wood stove is not properly installed, a house fire may result. For your safety, please follow the installation directions. Contact local building or fire officials...
- Page 2 NOTICE Gold plated surface must be cleaned with glass cleaner and a soft rag before firing the first time, or fingerprints will remain.
-
Page 3: Table Of Contents
Pg. 8 Section 5 Additional Safety Precautions Pg. 9 Section 6 Operating & Building an Efficient Fire Pg. 10 Building a Fire in the 1500 Building a Fire in the 2500 Maintenance Section 7 Troubleshooting Guide Pg. 11 Section 8 Warranty Pg. -
Page 4: Fireplace Insert Installation
1. Position the Stove so that it is centered in the opening horizontally. Set Stove so top front edge is out in front of opening approx. 7” for 1500 and 9” for 2500. If you are using a direct connect with flue pipe, be sure to install/connect now. -
Page 5: Stove Glass
Section 2: Stove Glass Tools Required: 3/16” Allen Wrench & Knife Materials: High·Temperature Glass 6 ft. of 1/8” x 1” Gasket with Adhesive Glass Installation 1. Glass can be installed in the door opening with the door on the stove. 2. -
Page 6: Freestanding Installation
Section 3: Free Standing Stove Installation Tools Required: 9/16” Wrench Materials: 4 3/8” x 3/4” Bolts NOTE: Dimensions shown are clearances to a combustible wall. General Safety Information Proper installation of any wood burning stove is necessary for the safety and effective- ness of its operation, Check with your dealer regarding arrangements for installing your free standing model. - Page 7 6. Use only an insulated, all-fuel chimney to vent the hot gases out of the house. It will reduce the amount of creosote buildup and improve the draft needed to vent hot gases from the stove. 7. Use an 8” diameter insulated thimble or an 8” diameter insulated all-fuel chimney section when passing through a combustible wall or ceiling.
-
Page 8: Installation Of Legs Or Pedestal
1/4” x 20 cap screws, has been placed into the firebox of the stove. Please follow steps below to install bower. Blower for Model 1500 is already installed. 1. Remove the front blower cover locate the opening for the blower. -
Page 9: Additional Safety Precautions
Section 5: Additional Safety Precautions 1. Ash Disposal: Ashes should be placed in a metal container with a tight fitting lid. The closed container of ashes should be placed on a non-combustible floor or on the ground, well away from combustible materials, pending final disposal. If the ashes are disposed of by burial in sailor otherwise locally dispersed they should be retained in the closed container until all cinders have thoroughly cooled. -
Page 10: Operating & Building An Efficient Fire
Section 6: Operating and Building an Efficient Fire For the High Valley Model 1500 1. Pull Catalyst Bypass (top center handle) completely open (pull to open, push to close) to bypass the catalyst until it reaches operating temperature (500°F) 2. Pull Dampers (left and right) out all the way to open (pull to open, push to close). -
Page 11: Troubleshooting Guide
Section 7: Troubleshooting Guide Problem Remedy 1. Cannot start fire. • Open catalyst bypass damper. • Open combustion air dampers underneath hearth plate. • Burn out flue by rolling up piece of newspaper lighting and holding in upper rear portion of firebox. This will cause the chimney to draw. 2. - Page 12 *The warranty will be void if coal is burned in any High Valley wood burning stove. General Warranty Provisions High Valley Stoves, warrants the model 2500 and 1500 against defects in material and workmanship for 5 years as long as it is owned by the original purchaser, provided that...
-
Page 13: Warranty
Warranty void if serial plate has been removed or defaced. Warranty gives you specific legal rights and you may also have other rights which vary from state to state. Obadiah's Wood Stoves 1660 Whalebone Dr. Kalispell, MT 59901 P: 800-968-6804 W: www.woodstoves.net... -
Page 14: Wiring Diagrams
Section 9: Wiring Diagrams 1500 Wiring Diagram 2500 Wiring Diagram www.woodstoves.net... -
Page 15: Section 10 Owner's Registration Card
Selling Price Less Tax: Date Purchased: Date Installed: Model Purchased: (select one) q 2500 q 1500 q ZC Cabinet ZC Serial Number: Wood Stove Serial Number: (found on rear of unit) Remove page from book then fold in half and tape. - Page 16 From: Place Stamp Here Obadiah's Warranty c/o Stoll 153 Hwy. 201 Abbeville, SC 29620...