Related Manuals for Xtreme Power Conversion TX90-1000
Summary of Contents for Xtreme Power Conversion TX90-1000
- Page 1 TX90 Isolated Online UPS 1000VA, 2000VA, 3000VA, 5000VA Models User & Installation Manual www.xpcc.com | © 2015 Xtreme Power Conversion Corporation. All rights reserved. (Rev 4/06/15)
-
Page 2: Table Of Contents
Audible Alarm..........................12 LCD Display Wordings Index......................12 UPS Setting............................13 Operating Mode Description......................17 Faults Reference Code........................18 Warning Indicator..........................18 Troubleshooting..................19 Storage And Maintenance Operation............21 Specifications.....................22 Obtaining Service..................23 Xtreme Power Conversion Limited Warranty..........24 Xtreme Power Conversion Load Protection Policy........25 Xtreme Power Conversion Corporation Page 2... -
Page 3: Important Safety Warning
• Caution - risk of electric shock. Even after the unit is disconnected from the mains (building wiring outlet), components inside the UPS system are still connected to the battery and electrically live and dangerous. • Before carrying out any kind of service and/or maintenance, disconnect the batteries and verify that no Xtreme Power Conversion Corporation Page 3... - Page 4 • Do not open or destroy batteries. Escaping electrolyte can cause injury to the skin and eyes. It may be toxic. • Please replace the fuse only with the same type and amperage in order to avoid fire hazards. • Do not dismantle the UPS system. Xtreme Power Conversion Corporation Page 4...
-
Page 5: Installation And Setup
Installation And Setup Note: Before installation, please inspect the unit. Be sure that nothing inside the package is damaged. Please keep the original package in a safe place for future use. Rear Panel View TX90-1000 TX90-2000 Xtreme Power Conversion Corporation Page 5... - Page 6 1. Output receptacles 2. AC input 3. Input circuit breaker 4. External battery connection (only available for L model) 5. RS-232 communication port 6. Modem/Phone line/Network surge protection 7. Intelligent slot 8. Output circuit breaker Xtreme Power Conversion Corporation Page 6...
-
Page 7: Setup The Ups
Step 4: Network connection Connect a single modem/phone/fax line into surge-protected “IN” outlet on the back panel of the UPS unit. Con- nect from “OUT” outlet to the equipment with another modem/fax/phone line cable. Xtreme Power Conversion Corporation Page 7... - Page 8 To calculate accurate backup time of external batteries, it’s necessary to configure battery numbers in software. The standard calculated capacity for one battery is 9Ah. If connecting to 100Ah batteries, then it’s equal to 11 in parallel (100Ah / 9Ah ≈ 11 sets). Xtreme Power Conversion Corporation Page 8...
-
Page 9: Operations
This action will be ineffective when the input voltage is out of acceptable range. • Switch to UPS self-test mode: Press ON/Mute and OFF/Enter buttons ON/Mute + Select Button Simultaneously for 5 seconds to enter UPS self-testing while in AC mode or converter mode Xtreme Power Conversion Corporation Page 9... -
Page 10: Lcd Panel
Load information Indicates the load level by 0-25%, 26-50%, 51-75%, and 76-100%. Indicates overload. Indicates the load or the UPS output is short circuit. Mode operation information Indicates the UPS connects to the mains. Xtreme Power Conversion Corporation Page 10... -
Page 11: Audible Alarm
Sounding every second Overload Sounding twice every second Fault Continuously sounding Bypass Mode Sounding every 10 seconds LCD Display Wordings Index Abbreviation Display content Meaning Enable Disable Escape High loss Low loss Battery Converter Temperature Charger Xtreme Power Conversion Corporation Page 11... -
Page 12: Ups Setting
For 110/115/120/127 VAC models, you may choose the fol- lowing output voltage: 110: presents output voltage is 110Vac 115: presents output voltage is 115Vac 120: presents output voltage is 120Vac 127: presents output voltage is 127Vac Xtreme Power Conversion Corporation Page 12... - Page 13 For 208/220/230/240 VAC models, the setting range is from -7V to -24V of the nominal output voltage For 110/115/120/127 VAC models, the setting range is from -3V to -12V of the nominal output voltage. Xtreme Power Conversion Corporation Page 13...
- Page 14 51.0Hz to 55.0Hz; 45.0-49.0:setting high frequency point from 45.0Hz to49.0Hz; For 60Hz models: 61.0-65.0:setting high frequency point from 61.0Hz to 65.0Hz; 55.0-59.0:setting high frequency point from 55.0Hz to 59.0Hz; Xtreme Power Conversion Corporation Page 14...
- Page 15 09: Battery AH setting Interface Setting Press the function key to set the Battery AH of UPS. 0-999: if you change the battery AH of UPS, please set the cor- rect AH for the ups. Unit (AH) Xtreme Power Conversion Corporation Page 15...
-
Page 16: Operating Mode Description
UPS is overload, UPS will enter bypass mode or bypass mode can be set by front panel. Alarm Bypass mode is sounding every 10 second. UPS is powered off and no output supply power, Standby mode but still can charge batteries. Xtreme Power Conversion Corporation Page 16... -
Page 17: Faults Reference Code
Sounding twice every second Battery is not connected Sounding every second Over Charge Sounding every second Over temperature Sounding every second Charger failure Sounding every second Out of bypass voltage range Sounding every second Xtreme Power Conversion Corporation Page 17... -
Page 18: Troubleshooting
1. The load is still supplied, but 11, 12, 13 and 41 on LCD display directly from AC power via Contact your dealer and alarm is continuously sound- bypass. ing. 2. The load is no longer supplied by power. Xtreme Power Conversion Corporation Page 18... - Page 19 If Batteries are not fully charged the problem still persists, consult Battery backup time is shorter than your dealer. nominal value Contact your dealer to replace the Batteries defect battery. Xtreme Power Conversion Corporation Page 19...
-
Page 20: Storage And Maintenance Operation
Before storing, charge the UPS 5 hours. Store the UPS covered and upright in a cool, dry location. During storage, recharge the battery in accordance with the following table: Storage Temperature Recharge Frequency Charging Duration -20°C - 40°C Every 3 months 1-2 hours 40°C - 45°C Every 2 months 1-2 hours Xtreme Power Conversion Corporation Page 20... -
Page 21: Specifications
Caster base, input cord sets, output receptacles (including NEMA L6-20R, L6-30R, or 6-15/20R), power distribution (XPDU) *Depending on load level **TX90 capacity derates 20% at 100V output ***TX90i 1000-3000 capacity derates 20% at 200V and 208VAC output voltage ****TX90i-5000 capacity derates 20% at 200/208VAC output voltage Xtreme Power Conversion Corporation Page 21... -
Page 22: Obtaining Service
RMA number marked on the outside of the boxes. 4. Return the UPS by insured, prepaid carrier to the address provided by the Technician. 5. Refer to the Warranty statements in this manual for additional details on what is covered. Xtreme Power Conversion Corporation Page 22... -
Page 23: Xtreme Power Conversion Limited Warranty
Purchaser’s sole and exclusive remedy for breach of any warranty, expressed or implied, concerning Xtreme Power Conversion equipment, and the only obligation of XPC Corporation under this warranty, shall be the repair or replacement of defective equipment, components, or parts;... -
Page 24: Xtreme Power Conversion Load Protection Policy
TX90 User’s Manual Uninterruptible Power Supply Xtreme Power Conversion Load Protection Policy THIS POLICY IS NOT A WARRANTY. REFER TO THE XPC CORPORATION, INC. LIMITED WARRANTY FOR INFORMATION CONCERNING THE WARRANTY FOR YOUR XPC PRODUCT. THE LIMITATIONS AND CONDITIONS CONTAINED IN THIS POLICY DO NOT AFFECT THE TERMS OF THE XPC LIMITED WARRANTY. - Page 25 Purchaser and the name of the power utility supplier for the location of the Connected Equipment. XPC will forward to the Purchaser a Load Protection Policy claims form, which Xtreme Power Conversion Corporation Page 25...
- Page 26 No employee of XPC or any other party is authorized to make any representations beyond those made in this agreement con- cerning the Load Protection Policy. XPC Corporation 230 Yuma Street Denver, CO 80223 1.800.582.4524 Xtreme Power Conversion Corporation Page 26...