Harman TL2.6 Owner's Manual
Installation and operation
Hide thumbs
Also See for TL2.6:
- Owner's manual (44 pages) ,
- Owner's manual installation and operation (44 pages)
Table of Contents
Advertisement
Quick Links
Owner's Manual
Installation and Operation
Model:
TL2.6
Non-Catalytic, Top Load,
Wood Burning Room Heater
Item #1-90-857000- Pedestal
# 1-90-858000 - Leg
Contact your local dealer with questions on installation, operation or service.
•
Important operating and
maintenance instructions
included.
!
PLEASE READ THIS ENTIRE MANUAL
BEFORE INSTALLATION AND USE OF
THIS WOOD-BURNING ROOM HEATER.
FAILURE TO FOLLOW THESE
INSTRUCTIONS COULD RESULT IN
PROPERTY DAMAGE, BODILY INJURY
OR EVEN DEATH.
• DO NOT STORE OR USE GASOLINE OR OTHER
FLAMMABLE VAPORS AND LIQUIDS IN THE
VICINITY OF THIS OR ANY OTHER APPLIANCE.
• DO NOT OVERFIRE - IF ANY EXTERNAL PART
STARTS TO GLOW, YOU ARE OVERFIRING.
CLOSE AIR CONTROLS. OVERFIRING WILL VOID
YOUR WARRANTY.
• COMPLY WITH ALL MINIMUM CLEARANCES TO
COMBUSTIBLES AS SPECIFIED. FAILURE TO
COMPLY MAY CAUSE A HOUSE FIRE.
!
TESTED AND APPROVED FOR USE WITH DRY,
SEASONED CORDWOOD ONLY. DO NOT BURN WET
OR GREEN WOOD. BURNING ANY OTHER TYPE OF
FUEL WILL VOID YOUR WARRANTY.
To obtain a French translation of this manual, please contact your dealer or visit www.harmanstoves.com.
Pour obtenir une traduction française de ce manuel, s'il vous plaît contacter votre revendeur ou visitez www.harmanstoves.com.
Save These Instructions
DO NOT DISCARD THIS MANUAL
•
Read, understand and
follow these instructions
for safe installation and
operation.
WARNING
CAUTION
Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15
NOTICE
•
Leave this manual with
party responsible for use
and operation.
HOT SURFACES!
GLASS AND OTHER SURFACES ARE
HOT DURING OPERATION AND COOL
DOWN.
HOT, WILL CAUSE BURNS.
•
DO NOT TOUCH GLASS UNTIL IT IS COOLED
•
NEVER ALLOW CHILDREN TO TOUCH GLASS
•
KEEP CHILDREN AWAY
•
CAREFULLY SUPERVISE CHILDREN IN SAME ROOM
AS FIREPLACE.
•
ALERT CHILDREN AND ADULTS TO HAZARDS OF HIGH
TEMPERATURES.
HIGH TEMPERATURES MAY IGNITE CLOTHING OR
OTHER FLAMMABLE MATERIALS.
•
KEEP CLOTHING, FURNITURE, DRAPERIES AND OTHER
FLAMMABLE MATERIALS AWAY.
CHECK BUILDING CODES PRIOR TO INSTALLATION.
•
INSTALLATION MUST COMPLY WITH LOCAL, REGIONAL, STATE
AND NATIONAL CODES AND REGULATIONS.
•
CONSULT LOCAL BUILDING, FIRE OFFICIALS OR AUTHORITIES
HAVING JURISDICTION ABOUT RESTRICTIONS, INSTALLATION
INSPECTION, AND PERMITS.
Wood Stove
Use & Care Video
!
WARNING
!
CAUTION
3-90-08570
Advertisement
Table of Contents
Related Manuals for Harman TL2.6
Summary of Contents for Harman TL2.6
-
Page 1: Installation And Operation
To obtain a French translation of this manual, please contact your dealer or visit www.harmanstoves.com. Pour obtenir une traduction française de ce manuel, s’il vous plaît contacter votre revendeur ou visitez www.harmanstoves.com. Save These Instructions Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 3-90-08570... - Page 2 TL2.6 Woodburning Stove Hearth & Home Technologies welcomes you to our tradition of excellence! By choosing a Harman appliance, you have become part of our commitment to meeting the heating needs of consumers with the most distinctive, powerful and responsible home heating products available.
-
Page 3: Table Of Contents
G. Building and Maintaining a Fire ....26 Save These Instructions Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 Dry Seasoned Wood Only! -
Page 4: Section 1: Listing & Code Approvals
Replace glass only with 5mm ceramic glass. Please contact your dealer for replacement glass if needed. D. Electrical Rating Optional Blower: 115 VAC, 60 Hz. <1 Amps Dry Seasoned Wood Only! Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 Save These Instructions... -
Page 5: Section 2: Special Warning And Notes
CO fumes are toxic and can be fatal. NEVER CONNECT THIS UNIT TO A CHIMNEY FLUE The TL2.6 is a natural draft system which relies on a properly SERVING ANOTHER APPLIANCE. designed chimney to remove CO and other combustion by- products from the stove. -
Page 6: Sections 3: Getting Started
Do NOT connect to any forced air distribution duct or system. Installation and service of this appliance should be performed by qualified personnel. Hearth & Home Technologies recommends Factory Trained or NFI Certified professionals. Dry Seasoned Wood Only! Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 Save These Instructions... -
Page 7: Component Locator
Remember to tighten the bolts to insure the side shields do not fall off. Outer Hole Cover (1-10-857014) Flue Collar Rear Shield Flue Cover Plate Safety Label Save These Instructions Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 Dry Seasoned Wood Only! -
Page 8: Pre-Use Checklist
The optional air distribution blower has been installed properly. A properly grounded electrical receptacle is available within reach of the blower's power cord (if installed). Dry Seasoned Wood Only! Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 Save These Instructions... -
Page 9: Section 4: Dimensions & Clearances
25-7/8" Top View applies to both (657mm) Pedestal and Leg Models Outside Air Kit 23-15/16" (607mm) 28-5/8" (727mm) Outside 25-7/8" Air Kit (657mm) Save These Instructions Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 Dry Seasoned Wood Only! -
Page 10: Clearances To Combustibles
This unit was not tested for installation into an Alcove. Follow NFPA 211 Table 13.6.1 "Clearances for Solid Fuel– Burning Appliances". Dry Seasoned Wood Only! Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 Save These Instructions... - Page 11 This unit was not tested for installation into an Alcove. Follow NFPA 211 Table 13.6.1 "Clearances for Solid Fuel– Burning Appliances". Save These Instructions Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 Dry Seasoned Wood Only!
-
Page 12: Floor Protection
51-3/16" x 32-1/2" (USA ONLY). NOTE: Floor protector States. In Canada, the side dimension is measured from the WILL NOT touch the wall. widest part of the appliance. Dry Seasoned Wood Only! Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 Save These Instructions... -
Page 13: Section 5: Chimneys & Venting
When installed and operated according to this manual, the with local authorities before beginning your installation. TL2.6 will produce enough hot gases to keep the chimney The NFPA (National Fire Protection Agency) permits four warm so that adequate draft is maintained throughout the methods for passing through a combustible wall. -
Page 14: The Chimney
3ft. - Above roof exit point Chimney 2ft. - Higher than anything within - THE 3-FOOT, 2-FOOT, 10 FOOT RULE 10ft. of the chimney. Dry Seasoned Wood Only! Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 Save These Instructions... - Page 15 THE CHIMNEY AND CONNECTOR MUST BE MAINTAINED IN GOOD CONDITION AND KEPT CLEAN. Save These Instructions Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 Dry Seasoned Wood Only!
-
Page 16: Factory Built Chimney
Chimney Connector The Chimney Connector Shall Not Pass Through an Attic or Roof Space, Closet or Similar Concealed Space, a Floor or Ceiling. Dry Seasoned Wood Only! Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 Save These Instructions... - Page 17 *Floor protection in accordance with Solid Fuel Appliance Listing The Chimney Connector Shall Not Pass Through an Attic or Roof Space, Closet or Similar Concealed Space, a Floor or Ceiling. Save These Instructions Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 Dry Seasoned Wood Only!
- Page 18 TL2.6 Woodburning Stove TL2.6 to Flue Fireplace Conversion (Minimum NFPA 211 Liner Connection) Flue liner with required air space Stainlesssteel chimney connector must extend to flue liner Minimum 8” masonry thickness in front of smoke chamber Airtight insulated clean-out Use damper adapter or seal with...
- Page 19 *Floor protection in accordance with solid fuel appliance listing The Chimney Connector Shall Not Pass Through an Attic or Roof Space, Closet or Similar Concealed Space, a Floor or Ceiling. Save These Instructions Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 Dry Seasoned Wood Only!
- Page 20 ** Check with your local building codes inspector for clearance. The Chimney Connector Shall Not Pass Through an Attic or Roof Space, Closet or Similar Concealed Space, a Floor or Ceiling. Dry Seasoned Wood Only! Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 Save These Instructions...
-
Page 21: Mobile Home Installation
FLOOR JOIST, WALL STUDS, OR CEILING (HUD), CFR 3280, PART 24. TRUSSES. • ANY SUPPORTING MATERIAL THAT WOULD AFFECT THE STRUCTURAL INTEGRITY. DO NOT INSTALL IN SLEEPING ROOM. Save These Instructions Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 Dry Seasoned Wood Only! -
Page 22: Section 7: Appliance Set-Up
NEVER DRAW OUTSIDE COMBUSTION AIR FROM WALL, FLOOR OR CEILING CAVITY AS WELL AS ENCLOSED SPACE SUCH AS AN ATTIC OR GARAGE Outside Air Attachment Dry Seasoned Wood Only! Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 Save These Instructions... -
Page 23: Optional Blower Kit
Use ONLY Blower Part #1-00-856002 With This Appliance. The optional blower kit installs easily to the rear of the TL2.6. First, remove the air jacket shield from the rear of the stove. Use the same four bolts to attach the blower as shown. -
Page 24: Section 8: Operating Instructions
DAMAGE TO THE STOVE AND COULD RESULT IN ALWAYS WEAR FIRE RETARDANT GLOVES WHEN A HOUSE FIRE. USE ONLY APPROVED FUELS AND OPERATING THE STOVE. FOLLOW ONLY THESE OPERATION GUIDELINES. Dry Seasoned Wood Only! Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 Save These Instructions... -
Page 25: Burning As A Fireplace
In tight construction, consider installing outside air to the appliance. EXHAUST STREAM SECONDARY AIR THRU BRICK SECONDARY AIR ENTERING EXHAUST STREAM SECONDARY AIR FLOW PRIMARY AIR FLOW Save These Instructions Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 Dry Seasoned Wood Only! -
Page 26: User Controls
You must have this charcoal bed established before heat settings. Do not, under any circumstances, alter the you close the bypass damper. configuration or operation of the air control lever. Dry Seasoned Wood Only! Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 Save These Instructions... - Page 27 TL2.6 Woodburning Stove Providing you have the charcoal bed described, close the The TL2.6 is designed to provide access to the ash pan bypass damper by pulling the handle toward the front of the without the need for opening the main door. Before opening stove. This will begin the highly efficient mode of operation...
-
Page 28: Section 9: Service & Maintenance
Harman wood stoves. Use of chemical creosote removal products will void the warranty of the Firedome combustion system. Dry Seasoned Wood Only! Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 Save These Instructions... -
Page 29: General Maintenance Procedures
REPLACEMENT. DO NOT ABUSE GLASS BY STRIKING OR SLAMMING THE DOOR CLOSED. THIS TYPE OF BREAKAGE IS NOT COVERED BY THE PRODUCT WARRANTY. Save These Instructions Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 Dry Seasoned Wood Only! - Page 30 Dry Seasoned Wood Only! Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 Save These Instructions...
-
Page 31: Section 10: Reference Materials
TL2.6 Woodburning Stove Section 10 - Reference Materials Wiring diagram Save These Instructions Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 Dry Seasoned Wood Only! -
Page 32: Service Parts Listings (Pedestal)
Service Parts Listings (Pedestal) TL2.6 W/Pedestal Service Parts Beginning Manufacturing Date: Sept 2011 Wood Stove Ending Manufacturing Date: Active 1-90-857000-1 Part number list on following page. 08/15 Save These Instructions Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 3-90-08570... - Page 33 Glass clips Set of 4 2-00-05202-4 Glass gasket 15 ft 1-00-2312 Glass w/Gasket 1-00-06932 Latch plate, roller & hardware 1-00-06903 Additonal service parts on following page Save These Instructions Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 3-90-08570...
- Page 34 Brushed Stainless 3-43-856015-7 Tile Trim Brushed Stainless 3-43-06729-7 Spring Clips (Required for installation of Tile Frame) Pkg of 20 3-31-232547-20 Additonal service parts on following page Save These Instructions Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 3-90-08570...
- Page 35 Screw, Hex Washer Slot T23 Zinc Thread Cutting ,1/4-20x5/8” Pkg of 100 3-30-3014-100 Screw,1/4”-20 x 3/8” Alloy Steel Black Oxide Button Head Cap Washer, 5/16” Zinc Plated SAE Flat Pkg of 50 3-30-0205-50 Save These Instructions Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 3-90-08570...
-
Page 36: Service Parts Listings (Legs)
Service Parts Listings (w/Legs) TL2.6 w/Legs Service Parts Beginning Manufacturing Date: Sept 2011 Wood Stove Ending Manufacturing Date: Active 1-90-858000-1 Part number list on following page. 08/15 Save These Instructions Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 3-90-08570... - Page 37 Ash door roller with hardware Set of 2 1-00-06904 Ash Door Wood Handle Pkg of 3 3-40-08746-3 Andiron with hardware and extensions 1-00-856010 Additonal service parts on following page Save These Instructions Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 3-90-08570...
- Page 38 1-10-857014 Pre 008850474 3-42-1990 Touch Up Paint Post 008850474 3-42-19905 Ashlip Trim Brushed Stainless 3-43-4722386-7 Door Trim Brushed Stainless 3-43-856015-7 Additonal service parts on following page Save These Instructions Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 3-90-08570...
- Page 39 Screw, Hex Washer Slot T23 Zinc Thread Cutting ,1/4-20x5/8" Pkg of 100 3-30-3014-100 Screw,1/4"-20 x 3/8" Alloy Steel Black Oxide Button Head Cap Washer, 5/16" Zinc Plated SAE Flat Pkg of 50 3-30-0205-50 Save These Instructions Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 3-90-08570...
-
Page 40: Warranty Policy
Limited 3 years Firebox and heat exchanger Lifetime All replacement parts 90 Days beyond warranty period See conditions, exclusions, and limitations on next page. 4021-645F 02-18-13 Page 1 of 2 Save These Instructions Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 3-90-08570... - Page 41 This warranty gives you specific rights; you may also have other rights, which vary from state to state. EXCEPT TO THE EXTENT PROVIDED BY LAW, HHT MAKES NO EXPRESS WARRANTIES OTHER THAN THE WARRANTY SPECIFIED HEREIN. THE DURATION OF ANY IMPLIED WARRANTY IS LIMITED TO DURATION OF THE EXPRESSED WARRANTY SPECIFIED ABOVE. 4021-645F 02-18-13 Page 2 of 2 Save These Instructions Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 3-90-08570...
- Page 42 Service & Maintenance Log Date Of Service Performed By Description Of Service Save These Instructions Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 3-90-08570...
- Page 44 Printed in U.S.A. Save These Instructions Harman® • TL2.6 Owner's Manual_R25 • 2011 -___ • 09/15 3-90-08570...